Removal of polycyclic aromatic hydrocarbons and phenols from coking wastewater by simultaneously synthesized organobentonite in a one-step process

The optimal condition for a one-step process removing organic compounds from coking wastewater by simultaneously synthesized organobentonite as a pretreatment was investigated. Results showed that sorption of organic compounds by organobentonite was positively correlated to the cation surfactant exchange on the bentonite and the octanol-water partition coefficient (K_ow) of the solutes. With 0.75 g/L bentonite and 180 mg/L (60% of bentonite cation exchange capacity) cetyltrimethylammonium bromide, the removal efficiencies of the 16 polycyclic aromatic hydrocarbon (PAHs) specified by the US Environmental Protection Agency in coking wastewater except naphthalene were more than 90%, and that of benzo(a)pyrene was 99.5%. At the same time, the removal efficiencies of COD_Cr, NH₃-N, volatile phenols, colour and turbidity were 28.6%, 13.2%, 8.9%, 55% and 84.3%, respectively, and the ratio of BOD₅/COD_Cr increased from 0.31 to 0.41. These results indicated that the one-step process had high removal efficiency for toxic and refractory hydrophobic organic compounds, and could improve the biodegradability of the coking wastewater. Therefore it could be a promising technology for the pretreatment of toxic and refractory organic wastewater.     

Steady performance of a zero valent iron packed anaerobic reactor for azo dye wastewater treatment under variable influent quality

Zero valent iron (ZVI) is expected to help create an enhanced anaerobic environment that might improve the performance of anaerobic treatment. Based on this idea, a novel ZVI packed upflow anaerobic sludge blanket (ZVI-UASB) reactor was developed to treat azo dye wastewater with variable influent quality. The results showed that the reactor was less influenced by increases of Reactive Brilliant Red X-3B concentration from 50 to 1000 mg/L and chemical oxygen demand (COD) from 1000 to 7000 mg/L in the feed than a reference UASB reactor without the ZVI. The ZVI decreased oxidation-reduction potential in the reactor by about 80 mV. Iron ion dissolution from the ZVI could buffer acidity in the reactor, the amount of which was related to the COD concentration. Fluorescence in situ hybridization test showed the abundance of methanogens in the sludge of the ZVI-UASB reactor was significantly greater than that of the reference one. Denaturing gradient gel electrophoresis showed that the ZVI increased the diversity of microbial strains responsible for high efficiency.     

零价铁还原和吸附去除水中污染物的研究进展

近年来,零价铁以其低毒、廉价、易操作且对环境不会产生二次污染等优点,在水污染治理中受到重视。文章介绍了零价铁处理污水的机理,对利用零价铁的还原和吸附作用去除污水中的氯代有机物、硝基芳香族化合物、偶氮染料、重金属、高氯酸盐、硝酸盐等的研究情况进行了综述,指出了零价铁废水处理技术的研究方向。     

煤液化催化剂生产废水处理工艺设计和运行

采用斜板沉降-流砂过滤-蒸发器-结晶器工艺来处理煤液化催化剂生产废水。本文对该项目的催化剂生产废水处理工艺路线进行了详细介绍,并对实际生产期间的运行数据做了总结分析。通过运行数据表明:该工艺线路技术可靠,产品水的各项指标均能稳定达到再生水用作工业用水水源的水质标准,满足了生产回用的目的,且能够实现长期连续稳定运行。     

自然循环污水处理技术的应用与创新

以示范工程为契机,引进、消化吸收国际先进污水处理技术和设计理念。该技术作为一项小型生活污水处理先进技术,具有较好的推广应用价值和前景,对于出水水质要求高、气候条件恶劣的地区应用优势明显,在低温、青藏高原地区较其它工艺技术更能适应。     

脱色剂Z60去除焦化废水色度的应用研究

在单因素影响试验基础上用正交实验法研究了脱色剂Z60对焦化废水色度的去除效果,对最佳反应时间、温度、药剂投加量进行了初步试验研究,试验表明：在搅拌强度满足均匀混合条件下,反应温度25oC,絮凝沉降时间40min,色度去除率达80％以上,色度低于50倍。     

利用固定化藻菌耦合系统同步去除污水中的COD和氮磷

利用活性污泥和莱茵衣藻建立了一套固定化藻菌耦合系统同步去除污水中的COD和氮磷.系统污水日处理量为6 m3,水力停留时间为12 h.对于活性污泥部分,当厌氧槽搅拌转速为15 r.min-1,好氧槽DO值为5 mg.L-1时COD由150 mg.L-1左右降到50 mg.L-1,氨氮从20～30 mg.L-1降到0.5 ...     

三维电极处理腈纶聚合废水的条件优化研究

采用填充粒状活性炭的三维电极处理腈纶聚合废水,考察实验条件对污染物去除效果的影响以及废水处理前后可生化性的变化.阳极为Ti/SnO₂-Sb₂O₃网状极板,阴极为网状钛电极,分别考察了停留时间、 电解电压、 pH值、 曝气量对废水中污染物去除效果的影响.结果表明,电解电压和pH值对废水有机物的去除率影响较大,在最优实验条件：电解电压为15V,pH值为3,曝气量400 mL/min的条件下电解120 min,腈纶聚合废水的COD、 TOC和丙烯腈的去除率分别为32.59%、 22.17%和89.70%,并且经过电解处理,废水BOD₅/COD值从0.02上升至0.42,可生化性显著提高,为生物处理提供了条件.     

成核方式对诱导结晶工艺处理含铜废水的影响

研究了诱导结晶过程中成核方式对诱导结晶工艺处理含铜废水的影响.在2组严格控制的实验条件下,分别考察均相成核和非均相成核下诱导结晶工艺运行效果,并利用扫描电镜（SEM）、X射线能谱分析（EDS）等手段考察了2种成核方式下回收的结晶产物的生长状态以及纯度.结果表明,当废水中铜的浓度为50 mg.L-1时,均相成核条件下,结...     

高碳氮负荷下同时脱氮除碳好氧颗粒污泥研究

在4 L反应器中,以补加葡萄糖和硫酸铵的猪场废水为基质,不接种活性污泥,加入粉末状活性炭对废水土著微生物进行预固定.通过批次进水并控制运行条件（逐渐提高COD、NH 4＋-N负荷、缩短沉降时间、提高曝气量）培养同时脱氮除碳好氧颗粒污泥,研究了该好氧颗粒污泥的脱氮除碳功能及对高碳氮负荷冲击的响应.结果表明,成熟好氧颗粒污泥为土黄色不规则球状,粒径为0.5～3.5 mm.COD和NH 4＋-N负荷分别在4.80～12.6 kg.（m3.d）-1和0.217～0.503 kg.（m3.d）-1时,好氧颗粒污泥对COD的去除率〉94%,对NH 4＋-N的去除率〉98%.当COD和NH 4＋-N负荷分别提高至15.70 kg.（m3.d）-1和0.723kg.（m3.d）-1并运行4 d后,反应器内絮体激增,颗粒沉降变差并开始破碎,NH 4＋-N去除率下降至81.6%.排出部分污泥并降低负荷继续运行,颗粒污泥的NH 4＋-N去除率可迅速恢复至98%以上.本研究培养的好氧颗粒污泥具有良好的同时脱氮除碳功能,可以耐受高COD和NH 4＋-N负荷的双重冲击.